TFS125G.doc v e rsion 1.2 05.11.2002 vi telefilter filter specification tfs 125 g 1/5 ______________________________________________________________________________________________________ vi telefilter p o t s d a m e r s t r a ? e 1 8 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m measurement condition ambient temperature: 23 c input pow er level: 0 dbm source impedance: 200 ? balanced load impedance: 50 ? single ended terminating impedances: *) input: 880 ? // -11,0 pf output: 890 ? // -12,6 pf ch aracteristics remark: reference lev e l for the relativ e attenuation a rel of the tfs 125g is the attenuation at 125 mhz. refe rence for the echo response attenuation is the main time response lobe, the refer ence time is defined as t 0 . the nominal frequency f n is fix ed at 125 mhz w i thout tolerance. the giv en v a lues for the relativ e attenuation a rel and for the group delay ripple hav e to be reac hed at the frequencies giv en below ev en if the centre frequency f c is shifted due to the temper ature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a ty p. value limit a b solute attenuation w i thin f n 0,1 mhz 8 db 7 ...10 db nominal frequency f n - 125 mhz pass band ripple f n ..... f n 0,1 mhz - max. 0,25 db f n 0,1 mhz ... f n 0,2 mhz - max. 0,5 db f n 0,2 mhz ... f n 0,5 mhz - max. 1 db 1 db-bandw idth 1235 khz min. 1000 khz relativ e attenuation a rel f n ... f n 0,5 mhz - max. 1 db f n 1,2 mhz ... f n 1,8 mhz - min. 9 db f n 1,8 mhz ... f n 6 mhz 30 db min. 25 db f n 6 mhz ... f n 13 mhz 50 db min. 35 db f n - 13 mhz ... f n - 115 mhz 60 db min. 50 db f n + 13 mhz ... f n + 325 mhz 65 db min. 50 db echo response attenuation a rel t 0 + 2 s 42 db min. 30 db t 0 + 3 s 43 db min. 40 db t 0 + 4 s 56 db min. 50 db t 0 + 5 s 70 db min. 55 db t 0 + 6 s 75 db min. 60 db group delay @ f n 705 ns max. 750 ns group delay ripple w i thin f n 0,5 mhz 120 ns max. 150 ns input pow er lev e l - max. + 10 dbm vswr w i thin f n 0,5 mhz - min. 2:1 intermodulation products 62 dbm min. 60 dbm operating temperature range - 10 c ... + 85 c storage temperature range - 40 c ... + 125 c temperature coefficient of frequency tc f *** -0,036 ppm/k 2 - frequency inv e rsion temperature t 0 30 c - *) the terminating impedances depend on parasitics and q-v a lues of matching elem ents and the board used, and are to be understood as reference v a lues only . should there be additional questions, do not hesitate to ask fo r an application not e or contact our design team. **) f in,1 =125mhz; f in,2 =125,1mhz; p in =4dbm+loss @f n ; f out,1 =124,9mhz; f out,2 =125,2mhz; then p out <-56dbm ***) ? f(h z ) = t c f (ppm/k2) x (t-t 0 )2 x f to (mhz) generated: checked / approv ed: vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125G.doc v e rsion 1.2 05.11.2002 vi telefilter filter specification tfs 125 g 2/5 ______________________________________________________________________________________________________ vi telefilter p o t s d a m e r s t r a ? e 1 8 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m cons truc tion a nd pin c onfigura t ion (all dimensions in mm) 9,3 ma x . 5, 0 m ax . 1 2 3 4 5 6 7 8 9 10 1, 8 max . 7,1 2,54 0,1 0,10 0,8 2,8 2,54 0,1 2,54 0,1 6 0 1 2 3 4 5 6 7 8 9 10 t f s 125g p4 5 dat e co de 1 ground 2 ground 3 ground 4 output 5 ground 6 ground 7 ground 8 ground 9 input 10 input date code: y ear + w eek m 2000 n 2001 p 2002 .... .... matching circuit: input 200 ? balanced driv en / output 50 ? single ended 5 4 9 10 1, 2, 3, 6, 7 , 8 lb - i n ou t sa w l1 c1 c2 l3 l2 1 : 4 vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125G.doc v e rsion 1.2 05.11.2002 vi telefilter filter specification tfs 125 g 3/5 ______________________________________________________________________________________________________ vi telefilter p o t s d a m e r s t r a ? e 1 8 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m stability characteristics after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5g respectively , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions refer to the atta ched "air reflow temper ature conditions" on page 4; packin g tape & reel: iec 286 - 3, w i th exception of value for n and minimum bending radius; tape ty pe ii , embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 3000 reel of empty components at start: min 300 mm reel of empty components at start including leader: min 500 mm trailer min 300 mm d o p o e f w p 1 em bo s s ed c a r r i e r t a p e co ve r t a p e g p 2 b o a o d 1 t a p e ( a ll d i m e n s io n s in m m ) w : 1 6 0, 3 po : 4 0, 1 d o : 1 , 5 + 0 , 1 e : 1 , 75 0 , 1 f : 7, 5 0, 1 g (m i n ) : 0 , 6 0 p 2 : 2 0 , 1 p 1 : 8 0 , 1 d 1 ( m i n ) : 1, 5 a o : 5, 3 0 0, 1 b o : 9, 7 0 0, 1 ct c t : 1 3 , 5 0, 1 a c n w 1 w 2 reel (all dimensions in mm): a : 330 w1 : 16,40 +2,0 w2 (max) : 22,4 n (min) : 50 c : 13,0 0,5/-0.2 the minimum bending radius is 45 mm. the m ounting surface of the filters faces the bottom side of the embossed carrier tape. markings on the filters can be read if the upper side of the carrier tape is regarded w i th the sprocket holes on its right. vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125G.doc v e rsion 1.2 05.11.2002 vi telefilter filter specification tfs 125 g 4/5 ______________________________________________________________________________________________________ vi telefilter p o t s d a m e r s t r a ? e 1 8 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile name: pre-heating periods main-heat ing periods peak temperature t e mp eratu r e: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 t able for temperature vs. time during the air reflow process t o lerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125G.doc v e rsion 1.2 05.11.2002 vi telefilter filter specification tfs 125 g 5/5 ______________________________________________________________________________________________________ vi telefilter p o t s d a m e r s t r a ? e 1 8 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m history version reason of changes name date dev e lopment specification 1.0 generation of development specification chilla 1 7 . 0 7 . 2 0 0 2 1.1 terminating impedance (preliminary values) and ty pical values of re lative attenuation pfeiffer 25.09.2002 added 1.2 terminating impedance changed and ty pical values added pfeiffer 08.11.2002 vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
|
